Porsche Babblers  

Go Back   Porsche Babblers > Porsche Boxster and Cayman Forum > Boxster / Cayman

Boxster / Cayman Porsche Boxster and Cayman Forum - Topics and discussions about the Porsche Boxster and Cayman

Thread Tools
Old August 21st, 2002, 10:56 PM   #1
Magic Mtn Dan
Posts: n/a
GM offers an oil change monitor (light) - here's way too much info on oil

Oil Life Monitor Stripped Bare

(reprinted from General Motors)

The patented engine oil change technology involves computerized monitoring of engine revolutions, operating temperature, and other factors to optimize the change interval selection. The typical recommended interval for gasoline-fueled passenger cars and light-duty trucks is 3,000 miles (4,800 km) or three months, whichever first occurs, when outside temperatures are below freezing and trips are short. These conditions are considered severe duty. For ideal driving conditions, relating to long trips with mild outside temperatures, the interval can be expanded to 7,500 miles (12,000 km). Starting with the 2000 model year on certain vehicles, GM will raise the maximum mileage allowed for Oil-Life System-equipped vehicles to between 10,000 and 15,000 miles (16,000 and 25,000 km), depending on vehicle brand and engine*.

The development of the Oil-Life System began over a decade ago by researchers Shirley Schwartz and Donald Smolenski, both of the GM Research Laboratories. They discovered, through various investigations, that oil degradation, in general, followed pathways influenced by service and environmental conditions. The extremes of these conditions, as shown in Figure 1, are high-temperature, high-load on one end and low-temperature, low-load on the other. In between is the large operating domain representing the majority of driving conditions. The basic design of the Oil-Life System was intended to characterize extreme operating conditions and most points in between. While the Oil-Life System does not actually monitor any single quality or physical property of the oil, it does incorporate the use of a highly sophisticated mathematical model. This model applies the known influence of oil service temperature and revolutions to characterize the remaining life. The influence of temperature, in particular, has a marked impact on oil life. The almost parabolic nature of the aging rate with temperature emphasizes the importance of this as dependent variable. On the other hand, time or running time (in the absence of mileage or engine revolution data) was not found to be a particularly good indicator of oil life, since it did not adequately distinguish between periods of extended idle and periods when engine speed was high.

The onboard calculation of oil age was simplified by using penalty factors (as opposed to equations). A penalty factor is an indication of the rate of oil aging at a given operating temperature. For any given oil, higher penalty factors are associated with faster oil-aging rates. The model uses engine revolutions as a basis for measuring duration of service. Gathering the data to show correlation of on-board measurements of oil-change intervals to laboratory oil analysis is a slow process, requiring months or years. For example, a typical short-trip service test can last two years. During the original research program approximately 130,000 kilometers were accumulated in determining the constants for the mathematical model and another 160,000 kilometers were logged in testing vehicles equipped with the Oil-Life System. The four oil analysis tests are:

1. Total Acid Number (TAN)-Concentration of acid constituents in the oil from oil oxidation and combustion products.
2. Total Base Number (TBN)-Depletion of overbase detergent additive.
3. Differential Scanning Calorimetry (DSC)-Approximates the remaining life of the antioxidant (residual oxidation induction time).
4. Pentane Insolubles (PIN)-Concentration of carbon soot and sludge.

The point at which the oil-change indicator signaled an oil change is then shown. All oil analyses results are plotted, including those data points regarded as "outliers", that is, points with values differing by more than approximately 20 percent from the trend lines from all data. It is interesting that DSC data followed a rapid decay curve from the outset. Also interesting is that both TAN rises and TBN falls at an apparent increased rate near the point where PIN rises (about 16,000 km). Even though not all of these changes occurred with each vehicle and there was usually some oscillation in the data, it was still possible to use these generalizations as guidelines to characterize the oil aging process.

From these studies and other subsequent investigations it is clear that there are distinct benefits to drivers of vehicles equipped with the oil-life monitoring systems. For those who neglect to change their oil on a regular basis, the system provides reminders that a change is due. If they need the reminder and follow through with an oil change, they'll protect their engine from premature wear. And, drivers who thought they needed to get their oil changed every 3,000 miles (5,000 km) or so, might be able to go longer between changes. This will save them money, time, and perhaps more importantly, precious natural resources.

Ref: Schwartz, S. E. and D. J. Smolenski, "Development of an Automatic Engine Oil-Change Indicator System," SAE Paper 870403.

* General Motors has set the maximum distance for normal driving on the Chevrolet Avalanche equipped with the 5.3 liter and 8.1 liter V-8 gasoline powered engines at 10,000 miles.

Author Credit: General Motors Corporation
  Reply With Quote

  Porsche Babblers > Porsche Boxster and Cayman Forum > Boxster / Cayman

Thread Tools

Similar Threads
Thread Thread Starter Forum Replies Last Post
Oil Change Shahab Choudhry Boxster / Cayman 4 June 18th, 2003 10:10 PM
GGR Time Trials -- rule change & tech inspection Trygve Isaacson Boxster / Cayman 3 January 31st, 2002 10:48 PM
More interesting oil info Tool Pants Boxster / Cayman 4 November 30th, 2001 10:59 AM
Oil Change question - related to Jim Russel High Perf Driving School Asim Husain Boxster / Cayman 2 November 14th, 2001 11:36 PM
Track Info Joe Racing 0 April 15th, 2001 09:44 PM


Copyright © 2001-2014 Babblers. All rights reserved.
Babblers is a Porsche Boxster and Cayman enthusiast's forum, but it is in no way affiliated with, nor does it represent Porsche of Stuttgart, Germany.